TY - JOUR ID - 70972 TI - The Kinetics of Methanation on Nickel Catalysts JO - International Journal of Engineering JA - IJE LA - en SN - 1025-2495 AU - Cehn, Y. W. AD - Chemical & Petroleum Engineering, National Central University Y1 - 1988 PY - 1988 VL - 1 IS - 1 SP - 7 EP - 18 DO - N2 - An empirical rate equation was obtained for the methanation kinetics catalyzed by MCR-2X, a commercial catalyst prepared by Haldor-Topsoe. The studies were carried out in a fixed-bed reactor under differential conditions, and in a gradientless recycle reactor (Berry) over a range of total pressures, reactant concentractions (H2/CO ratios), and temperatures. The kinetics of methanation were found to be of first order in hydrogen at total gas pressures below 7 atm, and of half order at f-uigher pressures. With respect to carbon monoxide the reaction order was -0.46 in the composition range studied . Water vapor, a reaction product, was observed to inhibit the methanation rate. On the other hand, carbon dioxide and methane had no influence on the reaction kinetics. The following rate equation was obtained for the methanation rate with the partial pressure (p) of each component expressed in atmospheres and the rate constant k in mol.g-1 catalyst.s-1:The catalyst was observed to be susceptible to deactivation by hydrogen sulfide in the feed gas. The rate coefficient for deactivation was determined. Its value for MCR-2X was comparable to that of other nickelbased catalysts. UR - https://www.ije.ir/article_70972.html L1 - https://www.ije.ir/article_70972_d424d937cb2406a7dd9a3e345660a2f7.pdf ER -