Early Age Shrinkage Behavior of Triple Blend Concrete

Document Type: Original Article

Authors

Department of Civil Engineering, National Institute of Technology Raipur, Chhattisgarh, India

Abstract

The early age shrinkage is responsible for the early age cracking of concrete. It is very critical for durability of concrete. The change in volume of concrete due to evaporation of water or dehydration process is known as shrinkage. To reduce the early age shrinkage utilized the supplementary cementitious material (SCM) in concrete. In present research industrial and agricultural waste byproduct like fly ash (FA) and rice husk ash (RHA) along with cement were used as SCM. The triple blend concrete was prepared by the combination of 20%, 30% and 40% partial cement replacement with FA and RHA for 0.30, 0.35 and 0.40 water-cement ratio. The concrete samples were tested by advanced  instrument as shrinkage cone meter were used for measure the shrinkage. The result shows that the early age shrinkage reduced with increasing the SCM content. The microstructure characteristics enhanced with raising the content of FA and RHA up to 30% replacement; that was due to the dense particle packing.

Keywords


1.     A. M. Neville, Adam, M. Properties of Concrete, Fifth edition, Pearson Education Limited, 2011.
2.     R. K. Mishra, R. K. Tripathi, and V. Dubey, “Early age shrinkage pattern of concrete on replacement of fine aggregate with industrial by-product” Journal of Radiation Research and Applied Sciences, Vol. 9, No. 4, (2016), 386-391, https://doi.org/10.1016/j.jrras.2016.05.003
3.     P. Nath and P. K. Sarker, “Effect of Mixture Proportions on the Drying Shrinkage and Permeation Properties of High Strength Concrete Containing Class F Fly Ash,” KSCE Journal of Civil Engineering, Vol. 17, No. 6, (2013), 1437-1445, doi: 10.1007/s12205-013-0487-6.
4.     A. Castel, S. J. Foster, T. Ng, J. G. Sanjayan, and G. R. I., “Creep and drying shrinkage of a blended slag and low calcium fly ash geopolymer Concrete,” Materials and Structures, Vol. 49, (2016), 1619-1628.doi: 10.1617/s11527-015-0599-1.
5.     Rath Badrinarayan, D. Shrish, and R. Gangadhar, “A Study on Early Age Shrinkage Behaviour of Cement Paste with Binary and Ternary Combination of Fly Ash and Pond Ash,” Indian Journal of Science and Technology., Vol. 9, No. 9, (2016), 1-6. doi: 10.17485/ijst/2016/v9i44/95189.
6.     Raut, M. V., and S. V. Deo. "Use of high volume fly ash on early age shrinkage in concrete for local hot and dry condition." Journal of Engineering Science and Technology, Vol. 13, No. 7 (2018), 2036-2046.
7.     Hu, X., Shi, Z., Shi, C., Wu, Z., Tong, B., Ou, Z. and De Schutter, G., “Drying shrinkage and cracking resistance of concrete made with ternary cementitious components,” Construction and Building Materials, Vol. 149, (2017), 406-415, doi: 10.1016/j.conbuildmat.2017.05.113.
8.     X. Hu, C. Shi, Z. Shi, B. Tong, and D. Wang, “Early age shrinkage and heat of hydration of cement-fly ash-slag ternary blends,” Construction and Building Materials, Vol. 153, (2017), 857-865. doi: 10.1016/j.conbuildmat.2017.07.138.
9.     S. Dueramae, W. Tangchirapat, P. Chindaprasirt, and C. Jaturapitakkul, “Autogenous and drying shrinkages of mortars and pore structure of pastes made with activated binder of calcium carbide residue and fly ash,” Construction and Building Materials, Vol. 230, (2020), 116962. doi: 10.1016/j.conbuildmat.2019.116962.
10.   B. Singh, M. R. Rahman, R. Paswan, and S. K. Bhattacharyya, “Effect of activator concentration on the strength , ITZ and drying shrinkage of fly ash/ slag geopolymer Construction and Building Materials, Vol. 118, (2016), 171-179, doi: 10.1016/j.conbuildmat.2016.05.008.
11.   V. N. Kanthe, S. V Deo, and M. Murmu, “Use of Mineral Admixture in Concrete for Sustainable Development,” International Journal of Innovative  Research in Science and Engineering, Vol. 3, No. 3, (2017), 279-284.
12.   M. Hojati and A. Radlin, “Shrinkage and strength development of alkali-activated fly ash-slag binary cements,” Construction and Building Materials, Vol. 150, (2017), 808-816. doi: 10.1016/j.conbuildmat.2017.06.040.
13.   A. L. G. Gastaldini, M. P. Da Silva, and F. B. Zamberlan, “Total shrinkage, chloride penetration, and compressive strength of concretes that contain clear-colored rice husk ash,” Construction and Building Materials, Vol. 54, (2014), 369-377. doi: 10.1016/j.conbuildmat.2013.12.044.
[14.  G. Shafabakhsh and S. Ahmadi, “Evaluation of Coal Waste Ash and Rice Husk Ash on Properties of Pervious Concrete Pavement,” International Journal of Engineering, Transaction B: Applications, Vol. 29, No. 2, (2016), 192-201, doi: 10.5829/idosi.ije.2016.29.02b.08.
15.   V. Sai Giridhar Reddy and V. Ranga Rao, “Eco-friendly Blocks by Blended Materials,” International Journal of Engineering Transaction B: Applications,, Vol. 30, No. 5, (2017), 636–642. doi: 10.5829/idosi.ije.2017.30.05b.02
16.   S. Sharma, T. Gupta, and R. K. Sharma, “Assessment of Mechanical Properties of Concrete Containing Granite Slurry Waste,” International Journal of Engineering, Transaction B: Applications, Vol. 29, No. 5, (2016), 599-605. doi: 10.5829/idosi.ije.2016.29.05b.021.
17.   Sharma, S. Kant Ransinchung, G D R NKumar and A. P.Roy,Kumar, “Comparison of Permeability and Drying Shrinkage of Self Compacting Concrete Admixed with Wollastonite Micro Fiber and Fly Ash,” International Journal of Engineering, Transaction B: Applications, Vol. 30, No. 11, (2017), 1681-1690. doi: 10.5829/ije.2017.30.11b.08
18.   D. B. Zhang, Y. Zhang, T. Cheng, “New Analytic Method for Subgrade Settlement Calculation of the New Cement Fly ash Grave Pile slab Structure,” International Journal of Engineering, Transactions A: Basics, Vol. 29, No. 10, (2016), 1364-1371. doi: 10.5829/ije.2016.29.10a.06
19.   P. N. Reddy and J. A. Naqash, “Effect of Antifreeze Admixtures on Cold Weather Concrete,” International Journal of Engineering, Transactions C: Aspects, Vol. 32, No. 3, (2019), 366-372. doi: 10.5829/ije.2019.32.03c.03.
20.   V. N. Kanthe, S. V. Deo, and M. Murmu, “Effect of Fly Ash and Rice Husk Ash as Partial Replacement of Cement on Packing Density and Properties of Cement,” International Journal of Innovative Technology Exploring Engineering, Vol. 8, No. 7, (2019), 1940-1945. Retrieval Number: G6316058719/19©BEIESP.
21.   V. N. Kanthe, S. V Deo, and M. Murmu, “Effect of fly ash and rice husk ash on strength and durability of binary and ternary blend cement mortar,” Asian Journal of Civil Engineering, Vol. 19, No. 8, (2018), 963-970. doi: 10.1007/s42107-018-0076-6.
22.   IS: 8112-2013, “Ordinary Portland cement 43 Grade-Specification,” Buro of Indian Standard, No. 2, (2013), 1-14.
23.   IS: 12062-2009, “Concrete Mix Proportioning- Guidelines,” Buro of Indian Standard, No. 1, (2009), 1–21.
24.   American Concrete Institute, “Guide for Modeling and Calculating Shrinkage and Creep in Hardened Concrete,” ACI 209.2R-08, (2008), 2-48.
25.   N. J. Gardner and J. W. Zhao, “Creep and Shrinkage Revisited,” Material Journal, Vol. 91, No. 2, (1994), 204-211.
26.   V. Kanthe, S. Deo, and M. Murmu, “Effect on Autogenous Healing in Concrete by Fly Ash and Rice Husk Ash,” Iranica (Iranian) Journal of Energy and Environment, Vol. 10, No. 2, (2019), 154-158. doi: 10.5829/ijee.2019.10.02.13.